Supercritical fluid chromatography for the analysis of natural dyes: From carotenoids to flavonoids.

Plant-derived natural dyes are used in a variety of formulated products, from food to cosmetics and pharmaceutics. In addition to their color, they also provide some bioactivity. While they are mostly analyzed with high-performance liquid chromatography, supercritical fluid chromatography was also employed for several dye families, mostly for carotenoids and chlorophylls, and more recently for anthraquinones and flavonoids. These supercritical fluid chromatography methods are described in this review. Because the dyes have different structures and structural variations (polarity, isomers, etc.), the best chromatographic system to achieve their separation is not always the same. Hydrophobic stationary phases are preferred for the most hydrophobic dyes (chlorophylls and carotenoids) while polar stationary phases are preferred for the polar dyes (anthraquinones and flavonoids). Regarding the mobile phase composition, chlorophylls and carotenoids are best eluted with moderate proportions of co-solvent in CO2 (about 40%), while the most polar glycosylated flavonoids require higher proportions of co-solvent and acidic additives. Because dyes are colorful, ultraviolet-visible detection is often sufficient, while mass spectrometry offers additional structural information. Furthermore, fundamental information can also be gained through chromatographic analysis of dyes: either solubility in supercritical fluids, in view of their extraction, or retention behavior providing an understanding of stationary phase properties.

The effect of tandem coupling of NicoShell and TeicoShell columns in sub/supercritical fluid chromatography on enantioresolution.

The coupling of columns in sub/supercritical fluid chromatography presents a great opportunity for influencing the separation efficiency and extending the selectivity of the separation system. Combinations of different types of chiral stationary phases could positively affect the enantioresolution if single ones are complementary to each other. In this work, two superficially porous particle (2.7 µm) macrocyclic glycopeptide-based columns, namely TeicoShell and NicoShell, were serially coupled and tested in sub/supercritical fluid chromatography for the first time. The influence of the column arrangement on the enantioseparation of structurally diverse biologically active compounds was examined. The obtained results showed how the column order crucially affected the enantioresolution of compounds tested, but the retention was negligibly affected in most cases. We also demonstrated that single TeicoShell and NicoShell columns are very promising towards the development of highly efficient and fast/ultrafast sub/supercritical fluid chromatography methods for structurally different chiral compounds. The optimized methods for sub-minute enantioselective separation of certain biologically important compounds were proposed.

A high-repetition-rate, fast temperature-programmed gas chromatograph and its online coupling to a supercritical fluid chromatograph (SFC × GC).

We present a fast gas chromatographic system that can be used as a second dimension in comprehensive two-dimensional (supercritical fluid × gas) chromatography (SFC × GC). The temperature of the short (1 m long) capillary column is controlled by a resistively heated coaxial stainless-steel tube. The electrical resistance and, therefore, temperature of the stainless-steel tube are measured by continuous monitoring of the current/voltage ratio. Highly repeatable heating rates of up to 2100 °C min-1 (35 °C s-1) are obtained, which should be high enough for the most demanding fast chromatograms. To reduce the cooling time between temperature programs, the column is cooled by injecting evaporating carbon dioxide into the space between the coaxial heater and the column. This gives cooling rates of 5100 °C min-1 (85 °C s-1), which allows quick succession of temperature programs. More repeatable heating profiles with stable GC retention times together with faster cooling are significant improvements on previous SFC × GC systems. Cycle times of four gas chromatograms per minute could readily be achieved, which allows efficient coupling to high-resolution stop-flow SFC in the first dimension. We demonstrate the fast chromatograph by separating fatty acid methyl esters, yielding information that would be useful in the food and biodiesel industries.

Rapid analysis of nine lignans in Schisandra chinensis by supercritical fluid chromatography using diode array and mass spectrometric detection.

Lignans are the bioactive constituents in Schisandra chinensis fruits. For the first time major representatives could directly be determined in plant extracts by using Supercritical Fluid Chromatography. Based on nine commercially available standards the method was developed, finally permitting their baseline separation in less than 10 min. The optimum setup showed to be a Viridis HSS C18 SB column, supercritical carbon dioxide and methanol. The compounds could be assigned in the extracts either at 210 nm or by MS, for which no modifications except of an additional sheath liquid (0.1 % acetic acid in methanol) were required. The determined lignan patterns were typical for S. chinensis, with schisandrol A being the most abundant compound, followed by schisandrin B or schisandrol B. As method validation results also complied well with the requirements the here presented method is definitely an interesting alternative to established techniques like UHPLC for the analysis of lignans in Schisandra chinensis.

An automatic online solid-phase dehydrate extraction-ultra-high performance supercritical fluid chromatography-tandem mass spectrometry system using a dilution strategy for the screening of doping agents in human urine.

An automatic online solid-phase dehydrate extraction (SPDE)-ultra-high performance supercritical fluid chromatography (UHPSFC)-MS/MS system was developed in this study, in which the automatic SPDE procedure was coupled with UHPSFC to allow UHPSFC to analyze aqueous samples directly. Moreover, a pre-column dilution strategy was employed, which focused the analytes in strong desorption solvent on the column head and helped to obtain narrow and symmetric peaks. The online SPDE-UHPSFC-MS/MS system was firstly applied to the screening of 45 prohibited substances in human urine for doping control, during which all the mechanisms and features of the online system were fully studied. The majority (91%) of the target compounds achieved weak matrix effects (80-120%), indicating that the online method was accurate and reliable thanks to the SPDE procedure and efficient UHPSFC separation. Owing to the reduction of the matrix effects, large volume injection and the pre-column dilution, the online system could achieve high sensitivity with the LODs ranging from 0.0380 ng L-1 to 1.24 µg L-1. Under the optimized conditions, the extraction recoveries of 66% target analytes were more than 50%. All the target compounds showed good linearity with linear correlation coefficients higher than 0.9928. The accuracy values of all the spiked prohibited substances were within 80.8-119.7%, while the RSDs% for the intra-/inter-day precision were within 10.8% and 15.4%. Compared with the dilute-and-shoot-ultra-high performance liquid chromatography-MS/MS method, in which the urine samples were simply diluted before analyzing, this online method was superior in sensitivity and reducing matrix effects, which demonstrated its utility in doping control. Compared with the previously reported online SPE-SFC system, the online SPDE-UHPSFC-MS/MS system showed advantages in automation, efficiency, sensitivity and chromatographic performance. In summary, the online SPDE-UHPSFC-MS/MS system is capable of analyzing complex aqueous samples.

Evaluation of a series of phenyl-type stationary phases in supercritical fluid chromatography with the linear solvation energy relationship model and its application to the separation of phenolic compounds.

In recent years, supercritical fluid chromatography (SFC) has become a powerful tool in modern analytical chemistry, and the diversity of stationary phases in SFC promotes phenyl-type phases to confront with a significant resurgence of interest. In this paper, a series of phenyl-type stationary phases with different substituted benzenes involving N-propylbenzamide (PB), 4-fluoro-N-propylbenzamide (PB-F), and 4-ethyl-N-propylbenzamide (PB-ET) were synthesized. Retention mechanism of these phases in SFC was investigated using a linear solvation energy relationship (LSER) model. The phenyl-type stationary phases with all positive parameters can provide all types of interaction, typically involving hydrogen bonding, dipole-dipole and dispersive interactions. The different benzene's substituents of the stationary phases mainly affected their hydrogen bonding and dipole-dipole interactions, which could be reflected by the angle between the solvation vectors to some extent. The k-k plot showed that the selectivity difference of phenyl-type stationary phases was closely related to the type of solute. Thus, based on twenty-five natural phenolic compounds, two systems with high orthogonality (63.49%) were constructed using three columns, namely phenyl column (PHE) × PB-F and PB × PB-F. Finally, after investigating the influence of chromatographic conditions, ten flavonoids could be separated by using PB, PB-F and PHE columns in SFC.

Supercritical fluid chromatography-a technical overview and its applications in medicinal plant analysis: an update covering 2012-2018.

Medicinal plants with complex matrices are endowed with a wide scope of biological activities. The separation, quantification, characterization and purification of bioactive components from herbal medicine extracts have always challenged analysts. Fortunately, the advancement of various emerging techniques has provided potent support for improving the method selectivity, sensitivity and run speeds in medicinal plant analyses. In recent years, the advent of new-generation supercritical fluid chromatography (SFC) instruments and a wide diversity of column chemistries, coupled with the intrinsic technical features of SFC, have made it an alternative and prominent analytical platform in the medicinal plant research area. This work aims to give a comprehensive overview of the fundamentals, technical advancement and investigating parameters of SFC in combination with three prevalent detectors. Moreover, the latest research progress of SFC applications in medicinal plant analyses is illuminated, with focus on herbal medicine-related SFC papers on the analytical and preparative scale that were published during the period of 2012 to December 2018. The most relevant applications were classified based on the constituents to be analysed. As for the respective research cases, analytical protocols and data processing strategies were provided, along with the indicated restrictions or superiority of the method; thus, the current status of SFC in medicinal plant analysis was presented.

Application of Green Technology for the Acquisition of Extracts of Araçá (Psidium grandifolium Mart. ex DC.) Using Supercritical CO2 and Pressurized Ethanol: Characterization and Analysis of Activity.

Brazil is home to a wide variety of flora, including several lesser known species, such as araçá that were processed in this study using two green technologies consecutively: supercritical fluid extraction (SFE) for nonpolar fraction and pressurized liquid extraction. For polar fraction, the experiments followed a central composite design involving ethanol as solvent, with temperature and static time in each bath as independent variables. Both extracts were analyzed for antioxidant and antimicrobial activities. Total phenolics content (TPC) was determined for all ethanol extracts. In the araçá essential oil (AEO) obtained by SFE, the extraction yield was 2.33%. The three major compounds of AEO were α-pinene (20.75%), p-cymene (20.50%), and o-cymene (20.05%). In ethanol extracts, the high yield (14.49%) was obtained at 74 °C/6 min and the major TPC (136.95 mg GAE/100 g) at 60 °C/9 min. Ethanol extracts presented good antioxidant activity (EC50 = 6.37 mg/mL) at 74 °C/6 min. AEO was unable to reduce DPPH• concentration by 50%. Both extract types presented an inhibitory effect against Staphylococcus aureus, Pseudomonas aeruginosa, and Bacillus cereus, while only the ethanol extracts presented effect against Listeria monocytogenes. This work had the aim to present the innovation of the use of a whole typical Brazilian fruit that gives rise to extracts with excellent properties for employment in both the pharmaceutical and food industries.

Characterising polar compounds using supercritical fluid chromatography-nuclear magnetic resonance spectroscopy (SFC-NMR).

To detect and characterise compounds in complex matrices, it is often necessary to separate the compound of interest from the matrix before analysis. In our previous work, we have developed the coupling of supercritical fluid chromatography (SFC) with nuclear magnetic resonance (NMR) spectroscopy for the analysis of nonpolar samples [Van Zelst et al., Anal. Chem., 2018, 90, 10457]. In this work, the SFC-NMR setup was successfully adapted to analyse polar samples in complex matrices. In-line SFC-NMR analysis of two N-acetylhexosamine stereoisomers was demonstrated, namely N-acetyl-mannosamine (ManNAc) and N-acetyl-glucosamine (GlcNAc). ManNAc is a metabolite that is present at elevated concentrations in patients suffering from NANS-mediated disease. With our SFC-NMR setup it was possible to distinguish between the polar stereoisomers. Until now, this was not possible with the standard mass-based analysis techniques. The concentrations that are needed in the SFC-NMR setup are currently too high to be able to detect ManNAc in patient samples (1.7 mM vs. 0.7 mM). However, several adaptations to the current setup will make this possible in the future.

SFC for chiral separations in bioanalysis.

This review covers literature investigating methods for enantioselective chromatography using supercritical fluids as mobile phase constituents (SFC) in the field of bioanalysis. It provides an overview on method development and screening approaches published in scientific literature 2014-2018. Chiral stationary phases are used to create a chiral environment that allows for discrimination of enantiomers. Especially polysaccharide-based stationary phases are used in methods of recent investigations. In comparison to HPLC chiral SFC separation provides more selective cavity effects of inclusion-type chiral separation phases. Modifier and additive choices as well as further operating conditions like backpressure, temperature and flow rate are summarized and critically discussed. Further on, observed sample pretreatment and possible detection techniques are presented. SFC hyphenated to mass detection was found of major relevance and is therefore further discussed. Coupling of SFC with different detectors allows for straightforward use in bioanalysis. Interfacing MS detectors is generally performed including a make-up pump. Thus, applied make-up conditions were also reviewed. While most of the chiral separations in HPLC are performed in normal phase mode, and thus, challenge MS hyphenation, SFC-MS hyphenation can be easily achieved. This allows for convenient application in chiral trace analyses, often required in bioanalysis. Even worse in enantioseparation than in achiral chromatography, method development in SFC suffers from a lack of knowledge in separation mechanisms and thus approaches are often quite unique and most often achieved by screening using a One-Factor-at-a-Time (OFAT) design. Broad screening experiments with methodical approaches still appear as method of choice for now.

Supercritical fluid chromatography-tandem mass spectrometry for high throughput bioanalysis of small molecules in drug discovery.

Liquid chromatography tandem mass spectrometry (LC-MS/MS) has been a golden standard for high throughput small molecule bioanalysis in drug discovery for decades. Supercritical fluid chromatography (SFC) has caught more attention in recent decade due to its advantages of greener mobile phase, lower backpressure and higher separation power. For the first time, we evaluated supercritical fluid chromatography tandem mass spectrometry (SFC-MS/MS) as a high throughput technique for bioanalysis of small molecule drug candidates and compared it to reversed phase LC-MS/MS. Twenty five compounds with diversified structures were evaluated using combination of 6 achiral columns and 4 different mobile phase compositions. To be able to make direct comparison between SFC and HPLC, same type of mass spectrometer was used as the detector. Extracted biological samples were injected to an SFC-MS/MS system and then re-injected to an LC-MS/MS system. It was found that the success rate of the SFC-MS/MS method development was more than 95% if using certain combinations of achiral column and mobile phase compositions without the time-consuming method scouting process. Sensitivity was established between 0.1 to 5.0 ng/mL for both SFC-MS/MS and LC-MS/MS with better sensitivity on SFC-MS/MS. Data from application studies correlated very well between the data produced by SFC-MS/MS and LC-MS/MS. Approximately 95% samples tested had ≤25% difference between SFC-MS/MS and LC-MS/MS data. It was demonstrated that SFC-MS/MS was comparable to golden standard LC-MS/MS and was an alternative choice for routine high throughput bioanalysis of small molecule drugs.

Extraction of Astaxanthin and Lutein from Microalga Haematococcus pluvialis in the Red Phase Using CO2 Supercritical Fluid Extraction Technology with Ethanol as Co-Solvent.

Astaxanthin and lutein, antioxidants used in nutraceutics and cosmetics, can be extracted from several microalgal species. In this work, investigations on astaxanthin and lutein extraction from Haematococcus pluvialis (H. pluvialis) in the red phase were carried out by means of the supercritical fluid extraction (SFE) technique, in which CO2 supercritical fluid was used as the extracting solvent with ethanol as the co-solvent. The experimental activity was performed using a bench-scale reactor in semi-batch configuration with varying extraction times (20, 40, 60, and 80 min), temperatures (50, 65, and 80 °C) and pressures (100, 400, and 550 bar). Moreover, the performance of CO2 SFE with ethanol was compared to that without ethanol. The results show that the highest astaxanthin and lutein recoveries were found at 65 °C and 550 bar, with ~18.5 mg/g dry weight (~92%) astaxanthin and ~7.15 mg/g dry weight (~93%) lutein. The highest astaxanthin purity and the highest lutein purity were found at 80 °C and 400 bar, and at 65 °C and 550 bar, respectively.

Supercritical Fluid Chromatography with Photodiode Array Detection in the Determination of Fat-Soluble Vitamins in Hemp Seed Oil and Waste Fish Oil.

In the presented study for the first time a new, optimized, fast SFC (supercritical fluid chromatography) method was applied to separate in one run fat-soluble vitamins from waste fish oil, including cis-and trans-retinyl palmitate, cis- and trans-retinyl acetate, retinol, α-tocopherol, ß-tocopherol, γ­tocopherol, δ-tocopherol, ergocalciferol (D2), cholecalciferol (D3), cis- and trans-phylloquinone (K1) and menaquinone-4 (K2-MK4). Vitamins were baseline separated on an Acquity UPC² (ultra performance convergence chromatography) HSS C18 SB (highly strength chemically modified silica) column within 13 min. The influence of the stationary phase, such as Torus 1-AA (1-aminoanthracene), Torus Diol (high density diol), Torus DEA (diethylamine), BEH (silica with no bonding), BEH-2EP (2-ethylpirydine), CSH Fluoro-Phenyl (silica with fluoro-phenyl groups), column temperature, flow rate and back pressure on the separation of the compounds was described. The application of the modified saponification procedure allowed us to increase concentration in the sample prepared for the analysis of γ­tocopherol from less than 1% (wt %) to 14% for the first time. In addition, α­tocopherol, γ­tocopherol, δ­tocopherol and retinol were identified in waste fish oil. Vitamin purification and analysis in waste fish oil are reported for the first time here. Due to the short time and effectiveness of the proposed method, it can be easily applied in industrial processes.

Designs and methods for interfacing SFC with MS.

Hyphenating SFC with MS is now routinely performed in analytical laboratories. Major instrument providers supply commercial solutions for coupling SFC and MS, which has facilitated wider adoption of the technology. The current status, however, could be achieved based on the work done by many researchers over decades. Interfacing SFC with MS posed some unique challenges, compared to interfacing MS with LC or GC, demanding special solutions. Several interface designs were tried and tested over the years before suitable solutions could be detected. Additional measures, such as (a) mixing SFC mobile-phase with an additional liquid solvent at the column outlet, and (b) heating the interfacing device, had to be adopted to address some specific challenges. Although such modifications and measures look diverse, there is one factor that drove most of them - compressibility of SFC mobile-phase. There are two objectives of this review - (1) to compile various insights which were reported on describing and optimizing SFC-MS interfacing processes, and (2) to link these insights with the fundamental issue of solvent compressibility.

Inactivation of the microbiota and effect on the quality attributes of pineapple juice using a continuous flow ultrasound-assisted supercritical carbon dioxide system.

Supercritical carbon dioxide inactivation technology represents a promising nonthermal processing method, as it causes minimum impact on the nutritional food properties. The aim of this study was to analyze the combined effect of supercritical carbon dioxide and high-power ultrasound on the inactivation of natural microbiota and the quality attributes of pineapple juice treated in a continuous flow system. Different juice residence times (3.06-4.6 min), at 100 bar and 31.5 ℃, were used. The results indicated that the microbiota inactivation was complete and the differences obtained in the quality attributes (2.2% for pH, 4.8% for °Brix, 2% for vitamin C) were minimal. During storage, microorganisms were not able to recover and the vitamin C decrease could be limited to 8.2% after four weeks. The results demonstrated that the supercritical carbon dioxide-high-power ultrasound technique could be an excellent alternative for the cold pasteurization of pineapple juice.

What are the current solutions for interfacing supercritical fluid chromatography and mass spectrometry?

Mass spectrometry (MS) is considered today as one of the most popular detection methods, due to its high selectivity and sensitivity. In particular, this detector has become the gold standard for the analysis of complex mixtures such as biological samples. The first successful SFC-MS hyphenation was reported in the 80's, and since then, several ionization sources, mass analyzers and interfacing technologies have been combined. Due to the specific physicochemical properties and compressibility of the SFC mobile phase, directing the column effluent into the ionization source is more challenging than in LC. Therefore, some specific interfaces have to be employed in SFC-MS, to i) avoid (or at least limit) analytes precipitation due to CO2 decompression, when the SFC mobile phase is not anymore under backpressure control, ii) achieve adequate ionization yield, even with a low proportion of MeOH in the mobile phase and iii) preserve the chromatographic integrity (i.e. maintaining retention, selectivity, and efficiency). The goal of this review is to describe the various SFC-MS interfaces and highlight the most favorable ones in terms of reliability, flexibility, sensitivity and user-friendliness.

Adiabatic packed column supercritical fluid chromatography using a dual-zone still-air column heater.

An approach to conducting SFC separations under pseudo-adiabatic condition utilizing a dual-zone column heater is described. The heater allows for efficient separations at low pressures above the critical temperature by imposing a temperature profile along the column wall that closely matches that for isenthalpic expansion of the fluid inside the column. As a result, the efficiency loss associated with the formation of radial temperature gradients in this difficult region can be largely avoided in packed analytical scale columns. For elution of n-octadecylbenzene at 60 °C with 5% methanol modifier and a flow rate of 3 mL/min, a 250 × 4.6-mm column packed with 5-micron Kinetex C18 particles began to lose efficiency (8% decrease in the number of theoretical plates) at outlet pressures below 142 bar in a traditional forced air oven. The corresponding outlet pressure for onset of excess efficiency loss was decreased to 121 bar when the column was operated in a commercial HPLC column heater, and to 104 bar in the new dual-zone heater operated in adiabatic mode, with corresponding increases in the retention factor for n-octadecylbenzene from 2.9 to 6.8 and 14, respectively. This approach allows for increased retention and efficient separations of otherwise weakly retained analytes. Applications are described for rapid SFC separation of an alkylbenzene mixture using a pressure ramp, and isobaric separation of a cannabinoid mixture.

Three newly identified lipophilic flavonoids in Tanacetum parthenium supercritical fluid extract penetrating the Blood-Brain Barrier.

Feverfew (Tanacetum parthenium L.) as a perennial herb has been known for centuries due to its medicinal properties. The main sesquiterpene lactone, parthenolide is considered to be responsible for the migraine prophylactic effect, however the pharmacological benefits of the lipophilic flavonoid components can not be neglected. Supercritical fluid extraction (7% ethanol, 22MPa, 64°C) was carried out on the leaves of Tanacetum parthenium L. from which the presence of methylated flavonoids beside parthenolide and other sesquiterpene lactones were indicated by preliminary LC-MS analyses. Specific Parallel Artificial Membrane Permeability Assay (PAMPA) was applied to identify the components capable to cross the Blood-Brain Barrier (BBB). Three lipophilic flavonoids were detected on the acceptor side, that were isolated (Prep-HPLC) and identified as sudachitin, aceronin and nevadensin (LC-MS/MS, NMR). These flavonoids were also characterized individually by PAMPA-BBB model. The presence of sudachitin and nevadensin was proven in the Asteraceae family, but neither of the three flavonoids were reported in Tanacetum parthenium L.

Development of a split-flow system for high precision variable sample introduction in supercritical fluid chromatography.

In this study, we propose a novel variable sample injection system based on full-loop injection, named the split-flow sample introduction system, for application in supercritical fluid chromatography (SFC). In this system, the mobile phase is split by the differential pressure between two back pressure regulators (BPRs) after full-loop injection suitable for SFC, and this differential pressure determines the introduction rate. Nine compounds with a wide range of characteristics were introduced with high reproducibility and universality, confirming that a robust variable sample injection system was achieved. We also investigated the control factors of our proposed system. Sample introduction was controlled by the ratio between the column-side pressure drops in splitless and split flow, ΔPcolumnsideinsplitless and ΔPcolumnsideinsplit, respectively, where ΔPcolumnsideinsplitless is related to the mobile phase flow rate and composition and the column resistance. When all other conditions are kept constant, increasing the make-up flow induces an additional pressure drop on the column side of the system, which leads to a reduced column-side flow rate, and hence decreased the amount of sample injected, even when the net pressure drop on the column side remains the same. Thus, sample introduction could be highly controlled at low sample introduction rate, regardless of the introduction conditions. This feature is advantageous because, as a control factor, the solvent in the make-up pump is independent of the column-side pressure drop.

Rapid and Green Separation of Mono- and Diesters of Monochloropropanediols by Ultrahigh Performance Supercritical Fluid Chromatography-Mass Spectrometry Using Neat Carbon Dioxide as a Mobile Phase.

This study demonstrates the effect of column selectivity and density of supercritical carbon dioxide (SC-CO2) on the separation of monochloropropanediol (MCPD) esters, known as food toxicants, using SC-CO2 without addition of cosolvent in ultrahigh performance supercritical fluid chromatography-mass spectrometry (UHPSFC-MS). This study shows that over 20 2-monochloropropanediol (2-MCPD) and 3-monochloropropanediol (3-MCPD) mono- and diesters are separated on a 2-picolylamine column in less than 12 min. The presence and position of a hydroxyl group in the structure, the number of unsaturated bonds, and the acyl chain length play a significant role in the separation of MCPD esters. The flow rate, backpressure, and column oven temperature, which affect the density of the mobile phase, were shown to have a substantial impact on retention, efficiency, and selectivity. The developed method was successfully applied for the determination of MCPD esters in refined oils and showed a close to excellent green analysis score using the Analytical Eco-Scale.